If you plan to cut any wood this upcoming long weekend, see below for THREE reminders on how to best prepare your woodpile. Just a few helpful tips!
Freshly cut green wood contains up to 50% moisture. That means that 50% of the weight of the wood is water.
When you try to burn green wood, you must first use up your precious BTUs from your fire to boil off the water in greenwood. Those are BTUs that could have gone into your home but instead are wasted.
Properly seasoned wood contains only 20% moisture.
So the 3 Most Important Steps are as follows:
Obviously, splitting your wood opens it up to allow it to dry much faster. A round log will never properly dry - it will start to rot before it has had enough time to dry. Anything over 6 inches in diameter gets split.
Stacking wood allows it to air-dry faster, particularly if you only stack the wood in narrow piles so the air can flow freely. Many people stack their wood on pallets to keep the bottom layer from rotting.
Cover your woodpile on the top from rain. Do not allow your cover to hang far over the edges of the pile as this prevents airflow.
The amount of time for proper seasoning depends upon many factors, but if you have a GASIFIER outdoor wood boiler, you should have already cut, split and stacked your wood for this upcoming winter. It will take at least 6 months for green hardwood to properly dry in order to burn properly in your GX Series or other gasification outdoor boiler. You actually should prepare your wood this summer for next Winter.
All other traditional outdoor wood boilers will sometimes operate a little better with some higher moisture content wood. This is because they are not high-efficiency furnaces and a load of really dry wood will burn up like a pile of match sticks, and too much of that heat will exit the chimney before it has a chance to transfer through your furnace walls into your water jacket. Do NOT burn all green wood, but also don't just burn 'matchstick dry' firewood in your outdoor boiler either.
So for these traditional outdoor boilers, it is ok to use wood that is less seasoned. We have some customers who mix some green wood in with their dry wood and they report that this works very well.
Video - EPA Blunders Again
While we may disagree on the EPA's blundering policy, they created this somewhat useful video on the topic. It is less than 2 minutes in length and worth watching. (Ignore the comments about the health risks of wood smoke - as if there are ANY types of smoke that are actually good for your health!)
Click BELOW to see the video.
And if I were you, I would NEVER put a woodpile that closes to a building!
But the EPA did get one thing right - Split, Stack, and Cover!
See below for more information in today's article. And don't forget to click here for some great laughs!
Free Support and Fast Answers
With FREE Technical Support, our hundreds of videos, articles, operations & maintenance tips, and FREE Design Services, we guarantee that we will provide you the right answer to your question or solution to your problem."
Our Customer Promise
Customer support begins with a great customer service team. Our dedicated team is trained and experienced in all things outdoor wood furnaces.
You can always expect a human on the other end of the line. We know what’s important to you - your family, saving money, and keeping your house toasty warm - and we make that our highest priority. Contact us!
Free Water Testing
One of the most important steps in prolonging the life of your outdoor boiler is to ensure that the water in your boiler is not corroding the steel. Water starts to eat holes in steel immediately upon contact (through rust corrosion) unless properly treated. We test your outdoor boiler water for free! Get your wood boiler water treatment now!
Send your water samples!